DIMENSION? PRO Urethane Integrating Clear DMI51/W
1 Proprietary Light Stabilizer
Material Safety Data Sheet ACGIH TLV Not Available
DCI51 OSHA PEL Not Available

Section 3 - Hazards Identification
01 00

Section 1 - Product and Company Identification ROUTES OF EXPOSURE
INHALATION of vapor or spray mist.
PRODUCT NUMBER HMIS CODES EYE or SKIN contact with the product, vapor or spray mist.
Health 2 EFFECTS OF OVEREXPOSURE
DCI51 Flammability 3 EYES: Irritation.
Reactivity 0 SKIN: Prolonged or repeated exposure may cause irritation.
PRODUCT NAME INHALATION: Irritation of the upper respiratory system.
DIMENSION* PRO Urethane Integrating Clear May cause nervous system depression. Extreme overexposure may result in
MANUFACTURER'S NAME EMERGENCY TELEPHONE NO. unconsciousness and possibly death.
WESTERN AUTOMOTIVE FINISHES (216) 566-2917 SIGNS AND SYMPTOMS OF OVEREXPOSURE
101 Prospect Avenue N.W. Headache, dizziness, nausea, and loss of coordination are indications of
Cleveland, OH 44115 excessive exposure to vapors or spray mists.
DATE OF PREPARATION INFORMATION TELEPHONE NO. Redness and itching or burning sensation may indicate eye or excessive
08-OCT-04 (216) 566-2902 skin exposure.
MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE
Section 2 - Composition/Information on Ingredients None generally recognized.
CANCER INFORMATION
% by WT CAS No. INGREDIENT UNITS VAPOR PRESSURE For complete discussion of toxicology data refer to Section 11.
EYES: Flush eyes with large amounts of water for 15 minutes.
3 67-64-1 Acetone Get medical attention.
ACGIH TLV 500 ppm 180 mm SKIN: Wash affected area thoroughly with soap and water.
ACGIH TLV 750 ppm STEL Remove contaminated clothing and launder before re-use.
OSHA PEL 1000 ppm INHALATION: If affected, remove from exposure. Restore breathing.
13 78-93-3 Methyl Ethyl Ketone Keep warm and quiet.
ACGIH TLV 200 ppm 70 mm INGESTION: Do not induce vomiting.
ACGIH TLV 300 ppm STEL Get medical attention immediately.
OSHA PEL 200 ppm
Section 5 - Fire Fighting Measures
OSHA PEL 300 ppm STEL
2 5440-89-1 5-Ethyl-2-nonanone
ACGIH TLV Not Available FLASH POINT LEL UEL
OSHA PEL Not Available 34 ??F PMCC 1.1 12.8
2 927-49-1 Diamyl Ketone FLAMMABILITY CLASSIFICATION
ACGIH TLV Not Available RED LABEL -- Flammable, Flash below 100 ??F
OSHA PEL Not Available EXTINGUISHING MEDIA
14 110-43-0 Methyl n-Amyl Ketone Carbon Dioxide, Dry Chemical, Foam
ACGIH TLV 50 ppm 2.14 mm UNUSUAL FIRE AND EXPLOSION HAZARDS
OSHA PEL 100 ppm Closed containers may explode when exposed to extreme heat.
15 123-86-4 n-Butyl Acetate Application to hot surfaces requires special precautions.
ACGIH TLV 150 ppm 10 mm During emergency conditions overexposure to decomposition products may
ACGIH TLV 200 ppm STEL cause a health hazard. Symptoms may not be immediately apparent. Obtain
OSHA PEL 150 ppm medical attention.
OSHA PEL 200 ppm STEL


IV-72
continued
DIMENSION? PRO Urethane Integrating Clear DMI51/W
SPECIAL FIRE FIGHTING PROCEDURES When sanding or abrading the dried film, wear a dust/mist respirator
Full protective equipment including self-contained breathing apparatus approved by NIOSH/MSHA for dust which may be generated from this product,
should be used. underlying paint, or the abrasive.
Water spray may be ineffective. If water is used, fog nozzles are PROTECTIVE GLOVES
preferable. Water may be used to cool closed containers to prevent Wear gloves which are recommended by glove supplier for protection
pressure build-up and possible autoignition or explosion when exposed to against materials in Section 2.
extreme heat. EYE PROTECTION
Wear safety spectacles with unperforated sideshields.
Section 6 - Accidental Release Measures OTHER PRECAUTIONS
Intentional misuse by deliberately concentrating and inhaling the
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED contents can be harmful or fatal.
Remove all sources of ignition. Ventilate the area.
Section 9 - Physical and Chemical Properties
Remove with inert absorbent.

Section 7 - Handling and Storage PRODUCT WEIGHT 7.99 lb/gal 956 g/l
SPECIFIC GRAVITY 0.96
STORAGE CATEGORY BOILING POINT 132 - 464 F 55 - 240 C
DOL Storage Class IB MELTING POINT Not Available
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE VOLATILE VOLUME 57 %
Contents are FLAMMABLE. Keep away from heat, sparks, and open flame. EVAPORATION RATE Slower than ether
During use and until all vapors are gone: Keep area ventilated - Do not VAPOR DENSITY Heavier than air
smoke - Extinguish all flames, pilot lights, and heaters - Turn off stoves, SOLUBILITY IN WATER N.A.
electric tools and appliances, and any other sources of ignition. VOLATILE ORGANIC COMPOUNDS (VOC Theoretical)
Consult NFPA Code. Use approved Bonding and Grounding procedures. 3.82 lb/gal 458 g/l Less Water and Federally Exempt Solvents
Keep container closed when not in use. Transfer only to approved 3.67 lb/gal 440 g/l Emitted VOC
containers with complete and appropriate labeling. Do not take internally.
Section 10 - Stability and Reactivity
Keep out of the reach of children.

Section 8 - Exposure Controls/Personal Protection STABILITY -- Stable
CONDITIONS TO AVOI PRECAUTIONS TO BE TAKEN IN USE None known.
Use only with adequate ventilation. INCOMPATIBILITY
Avoid contact with skin and eyes. Avoid breathing vapor and spray mist. None known.
Wash hands after using. HAZARDOUS DECOMPOSITION PRODUCTS
This coating may contain materials classified as nuisance particulates By fire: Carbon Dioxide, Carbon Monoxide
(listed "as Dust" in Section 2) which may be present at hazardous levels HAZARDOUS POLYMERIZATION
only during sanding or abrading of the dried film. If no specific dusts Will not occur
are listed in Section 2, the applicable limits for nuisance dusts are ACGIH
Section 11 - Toxicological Information
TLV 10 mg/m3 (total dust), 3 mg/m3 (respirable fraction), OSHA PEL 15 mg/m3
(total dust), 5 mg/m3 (respirable fraction).
VENTILATION CHRONIC HEALTH HAZARDS
Local exhaust preferable. General exhaust acceptable if the exposure to No ingredient in this product is an IARC, NTP or OSHA listed carcinogen.
materials in Section 2 is maintained below applicable exposure limits. Methyl Ethyl Ketone may increase the nervous system effects of other
Refer to OSHA Standards 1910.94, 1910.107, 1910.108. solvents.
RESPIRATORY PROTECTION Prolonged overexposure to solvent ingredients in Section 2 may cause
If personal exposure cannot be controlled below applicable limits by adverse effects to the liver, urinary, blood forming and reproductive
ventilation, wear a properly fitted organic vapor/particulate respirator systems.
approved by NIOSH/MSHA for protection against materials in Section 2.


IV-72
continued
DIMENSION? PRO Urethane Integrating Clear DMI51/W
Section 15 - Regulatory Information
Reports have associated repeated and prolonged overexposure to solvents
with permanent brain and nervous system damage.
SARA 313 (40 CFR 372.65C) SUPPLIER NOTIFICATION
TOXICOLOGY DATA
CAS No. Ingredient Name CAS No. CHEMICAL/COMPOUND % by WT % Element

67-64-1 Acetone 78-93-3 Methyl Ethyl Ketone 13
LC50 RAT 4HR Not Available
LD50 RAT 5800 mg/kg CALIFORNIA PROPOSITION 65
78-93-3 Methyl Ethyl Ketone WARNING: This product contains chemicals known to the State of
LC50 RAT 4HR Not Available California to cause cancer and birth defects or other reproductive harm.
LD50 RAT 2740 mg/kg TSCA CERTIFICATION
5440-89-1 5-Ethyl-2-nonanone All chemicals in this product are listed, or are exempt from listing,
LC50 RAT 4HR Not Available on the TSCA Inventory.
LD50 RAT Not Available
Section 16 - Other Information
927-49-1 Diamyl Ketone
LC50 RAT 4HR Not Available
LD50 RAT Not Available This product has been classified in accordance with the hazard criteria
110-43-0 Methyl n-Amyl Ketone of the Canadian Controlled Products Regulations (CPR) and the MSDS contains
LC50 RAT 4HR Not Available all of the information required by the CPR.
LD50 RAT 1670 mg/kg
123-86-4 n-Butyl Acetate
LC50 RAT 4HR 2000 ppm
LD50 RAT 13100 mg/kg
Proprietary Light Stabilizer
LC50 RAT 4HR Not Available
LD50 RAT 3125. mg/kg

Section 12 - Ecological Information

ECOTOXICOLOGICAL INFORMATION
No data available.


Section 13 - Disposal Considerations

WASTE DISPOSAL METHO Waste from this product may be hazardous as defined under the Resource
Conservation and Recovery Act (RCRA) 40 CFR 261.
Waste must be tested for ignitability to determine the applicable EPA
hazardous waste numbers.
Incinerate in approved facility. Do not incinerate closed container. The above information pertains to this product as currently formulated,
Dispose of in accordance with Federal, State/Provincial, and Local and is based on the information available at this time. Addition of
regulations regarding pollution. reducers or other additives to this product may substantially alter the
composition and hazards of the product. Since conditions of use are
Section 14 - Transport Information outside our control, we make no warranties, express or implied, and assume
no liability in connection with any use of this information.
No data available.


IV-72


5-ethylnonan-2-one