#127
MATERIAL SAFETY DATA SHEET
3 Flammability = 0 Reactivity = 0
NFPA RATING: Health =
3 Flammability = 0 Reactivity = 0
HMIS RATING: Health =

SECTION I ?? IDENTITY AND MANUFACTURER'S INFORMATION (0533A)
Manufacturer's Name: HILLYARD INDUSTRIES Product Name: H-101
Address: 302 North Fourth Street Date Prepared: February 8, 1995
St. Joseph, MO 64501 Prepared by: Regulatory Affairs Department
Emergency Telephone No.: (800) 424-9300 (Only in the event of chemical emergency involving a spill, leak, fire,
exposure or accident involving chemicals.) Other information calls: (816) 233-1321 (Ext. 8285)
http://www.hillyard.com
SECTION II ?? INGREDIENTS/IDENTITY INFORMATION
Components (Specific Chemical Identity: OSHA ACGIH OTHER LIMITS
Common Name(s) CAS# PEL TLV RECOMMENDED %
Octyl Decyl Dimethyl Ammonium Chloride
Dioctyl Dimethyl Ammonium Chloride
Didecyl Dimethyl Ammonium Chloride or Di-N- 68424-95-3 not not N/A 4.5
Alkyl (C8/C10-50%; C10-30%;C8/C8-20%) established established
dimethyl ammonium chloride
Alkyl (C14, 50%; C12, 40%; C16, 10%) Dimethyl 68424-85-1 not not N/A 3.0
Benzyl Ammonium Chloride established established
Ethyl alcohol 64-17-5 1000 ppm 1000 ppm N/A 1-2

SECTION III ?? PHYSICAL / CHEMICAL CHARACTERISTICS
Boiling Point: corr. 200oF 0.996 & 39oC = 0.989
Specific Gravity (H2O = 1): 25oC =
Vapor Pressure (mm Hg.): 17.6 average 91.36
Percent Volatile by Volume (%):
0.6 Evaporation Rate (ethyl ether = 1): less than 1
Vapor Density (AIR = 1):
Solubility in Water: appreciable Appearance and Odor: Clear, colorless liquid; non-objectionable odor
pH of concentrate: 5.0 -7.0
SECTION IV ?? FIRE AND EXPLOSION HAZARD DATA
Flash point: none to boiling (Tag Closed Cup) Flammable Limits: LEL = N/A UEL = N/A
Extinguishing Media: Water, dry chemical, CO2, foam
Special Fire Fighting Procedures: Wear MSHA/NIOSH approved self-contained breathing apparatus. Cool
fire-exposed containers with water spray.
Unusual Fire and Explosion Hazards: Products of combustion are toxic.
SECTION V ?? PHYSICAL HAZARDS
Stable Conditions to Avoid: Do not mix with anionic cleaners.
Stability:
Incompatibility (Materials to Avoid): Oxidizing materials
Hazardous Decomposition Products or Byproducts: Carbon dioxide, carbon monoxide, ammonia, nitrous
oxides, hydrogen chloride
Hazardous Polymerization: Will not occur Conditions to Avoid: None known
SECTION VI ?? HEALTH HAZARD DATA
Routes of entry: Inhalation? Yes Skin? Yes Ingestion? Yes
HEALTH HAZARDS (1. Acute and 2. Chronic)
1. Concentrate is corrosive to all body tissue with which it comes in contact.
2. Prolonged and repeated exposure to the skin may produce dermatitis. Inhalation of fine fog mist can cause
irritation of the mucous membranes; use large droplet sprayer and adequate ventilation when spraying or proper
respiratory protection.
Chemical listed as Carcinogen or Potential Carcinogen:
No No OSHA = No
National Toxicology Program = I.A.R.C. Monographs =
This product has no carcinogens listed by IARC, NTP, NIOSH, or ACGIH as of this date, greater than or equal to 0.1%.
page 2 of #127 - H-101

SECTION VI ?? HEALTH HAZARD DATA continued
Signs and Symptoms of Exposure: Direct eye contact can cause severe damage; repeated skin contact can cause severe skin
irritation; concentrate is corrosive to eyes and skin. Ingestion of concentrate: immediate burning pain in mouth, throat, abdomen and
severe swelling of larynx, skeletal muscle paralysis and affecting the ability to breathe.
Medical Conditions Generally Aggravated by Exposure: Skin problems such as industrial dermatitis.
Emergency and First Aid Procedures: In case of contact, immediately flush eyes or skin with plenty of water for at least 15
minutes. For eyes call a physician. Remove and wash contaminated clothing before reuse. If swallowed, drink promptly a large
quantity of egg whites, gelatin solution or if these are not available, drink large quantities of water. Avoid alcohol. Call a physician
immediately. Note to physician: Probable mucosal damage may contraindicate the use of gastric lavage.

SECTION VII -- PRECAUTIONS FOR SAFE HANDLING AND USE
Steps To Be Taken In Case Material Is Released Or Spilled: Dike and contain spill with inert material (sand, earth, etc.) and
transfer liquid and solid separately to containers for recovery or disposal. Small spills: Flush with water and pick up with wet vac or
mop when on inside flooring.
Waste Disposal Method: Pesticide wastes are acutely hazardous. Do not contaminate water, food or feed by storage or disposal. If
these wastes cannot be disposed of by use according to label instructions contact your state pesticide or Environmental Control
Agency, or the Hazardous Waste representative at the nearest EPA Regional Office for guidance.
Precautions To Be Taken In Handling And Storing: Do not store on side. Avoid creasing or impacting of side walls of package.
Other Precautions: Container disposal: triple rinse (or equivalent). Then offer for recycling or reconditioning or puncture and
dispose of in a sanitary landfill, or incineration, or if allowed by state and local authorities by burning. If burned stay out of smoke.
This product contains no reportable quantities of toxic chemicals subject to reporting requirements of Section 313 of Sara Title III
Emergency Planning and Community Right to Know Act of 1986 and 40 CFR Part 372.

SECTION VIII ?? CONTROL MEASURES
Respiratory Protection (Specify Type): Not required
Ventilation: 10 air changes per hour recommended
N/A Recommended N/A N/A
Local Exhaust = Mechanical (General) = Special = Other =
Protective Gloves: Rubber or neoprene with concentrate
Eye Protection: Chemical goggles or face shield with concentrate
Other Protective Clothing or Equipment: None
Work / Hygienic Practices: Wash thoroughly after handling

SECTION IX ?? TRANSPORTATION INFORMATION
Applicable regulations: DOT = Yes; IMCO = Yes; IATA = Yes
Proper shipping name (Gallon Boxes) for U.S. Highway: Consumer Commodity ORM- Proper shipping name (5 & 55 Gallon Drums) for U.S. Highway: Compounds, cleaning liquid, (Dialkyl dimethyl ammonium
chloride, N-alkyl dimethyl benzyl ammonium chloride), 8, NA 1760, PG III
UN No.: UN1760 Limited Qty.: not applicable Hazard Class: 8
Label required: Not required on gallon boxes by highway; 5 & 55 gallon drum = Corrosive Label
DOT Exception: Not applicable
EPA Hazardous waste/number code: Not listed
Hazardous waste characteristics:
Ignitability = Not applicable; Corrosivity = Not applicable; Reactivity = Not applicable

DISCLAIMER OF WARRANTIES
NO REPRESENTATIONS OR WARRANTIES, EITHER EXPRESS OR IMPLIED, OF MERCHANTABILITY, FITNESS
FOR A PARTICULAR PURPOSE, OR OF ANY NATURE ARE MADE WITH RESPECT TO THE PRODUCT(S) O INFORMATION CONTAINED IN THIS MATERIAL SAFETY DATA SHEET.
The information and recommendations contained in this Material Safety Data Sheet are supplied pursuant to 29 CF 1910.1200 of the Occupational Safety and Health Standards Hazard Communication Rule. All information contained herein
is presented in good faith and is believed to be appropriate and accurate.
THE BUYER OR USER ASSUMES ALL RISKS ASSOCIATED WITH THE USE, MISUSE OR DISPOSAL OF THIS
PRODUCT. THE BUYER OR USER IS RESPONSIBLE TO COMPLY WITH ALL FEDERAL, STATE OR LOCAL
REGULATIONS CONCERNING THE USE, MISUSE OR DISPOSAL OF THESE PRODUCTS.


Quaternary ammonium compounds, di-C8-10-alkyldimethyl, chlorides