Sandell Manufacturing Company, Inc.
Sandell
www.sandellmfg.com e-mail: moreinfo@sandellmfg.com

Sando-Dry Mastic
CORPORATE OFFICE BRANCH OFFICE
310 Wayto Rd. ?? Schenectady, NY 12303 1700 Vanderbilt Rd. ?? Birmingham, AL 35234
Phone: (518) 357-9757 Phone: (205) 263-1030
MATERIAL SAFETY DATA SHEET
1 (800) 283-3888 ?? Fax: (518) 357-9636 1 (877) SANDELL ?? Fax: (205) 263-1033


SECTION 1 SECTION 5 Precautions to be Taken in Handling and
Storage: Avoid breathing vapor or mist. Use
MATERIAL IDENTIFICATION AND USE REACTIVITY DATA
with adequate ventilation. Wear NIOSH/MSHA
Manufacturer: Sandell Manufacturing Co., Stability: Stable
approved respirators when exposure to vapors
Inc. Conditions to Avoid: Not applicable exceeds TLV. Keep containers closed when not
Chemical Family: Mixture in use. Do not take internally. Do not get in eyes,
Incompatibility: Strong oxiders
on skin or on clothing. Wash thoroughly after
Chemical Formula: Proprietary Hazardous Decomposition/ Combustion
handling.
Material Use: Sealant Products: Carbon monoxide, carbon dioxide,
Other Precautions: Keep out of reach of
nitrogen oxides and mixtures of toxic asphaltic
children.
fumes.
SECTION 2
Hazardous Polymerization: Will not occur.
HAZARDOUS INGREDIENTS
SECTION 8
Petroleum Asphalt: CAS #8052-42-4; ACHiH
EXPOSURE CONTROL
SECTION 6
TLV: 5.0 mg/m3; % Wt: <60%
Respiratory Protection: For fire conditions or
HEALTH HAZARD DATA
Mineral Spirits: CAS #64742-48-9; ACHiH
exposure above TLV wear NIOSH / MSHA
TLV: 100 ppm; % Wt: <30% Primary Routes of Entry: Inhalation, skin, &
approved respirators.
ingestion.
Isodecyloxy Propyl Amine Acetate:
Ventilation: Local exhaust is recommended.
CAS #28701-67-9; ACHiH TLV: 200 ppm; Effect of Overexposure (acute & chronic):
Protective Gloves: Yes, polyvinyl chloride
% Wt: <10% Will cause eye irritation. Repeated or prolonged
(PVC), neoprene, nitrile, polyvinyl alcohol (PVA)
skin contact may cause drying and defatting of
or viton gloves have been found to be effective.
the skin, leading to irritation. Inhalation of high,
SECTION 3 concentrated vapors may cause lethargy, Eye Protection: Safety goggles
PHYSICAL/CHEMICAL headache, dizziness, nausea, or narcosis.
Other Protective Clothing or Equipment: Not
CHARACTERISTICS Emergency and First Aid Procedures: applicable
Boiling Point: Not determined Inhalation: Remove to fresh air. If not breath- Hygienic Practices: Wash thoroughly after
Specific Gravity (H2O = 1): 1.2 ing, give artificial respiration. If breathing is handling, especially prior to eating or smoking.
difficult, give oxygen. Consult a physician. Wash clothing before reuse.
Vapor Pressure: Not determined
Skin: Wash thoroughly with soap and water. If
Boiling/Melting Point: Not determined
redness or irritation develops, obtain medical
SECTION 9
Vapor density: Not determined assistance.
REGULATORY INFORMATION
Evaporation Rate (Bu AC = 1): Not Eyes: Flush immediately with water at least 15
determined UN/NA ID Number: Not determined
minutes. Obtain medical assistance.
Solubility in Water: Insoluble RCRA Hazardous Waste: This product has a
Ingestion: Obtain medical assistance immedi-
flash point below 140??F (60??C). This product
Appearance and Odor: Black/Blue paste ately. Do not induce vomiting. Never give
falls within the flash point definition of ??Ignitable
solvent odor anything by mouth to an unconscious person.
waste?? as defined in 40CFR 261. Should this
Medical Conditions Aggravated by Exposure: product be discarded, it would be classified
Disorders or diseases of the skin, eye, res-
SECTION 4 as hazardous waste with the EPA waste number
piratory track or allergies. of D001.
FIRE AND EXPLOSION
Carcinogenicity: No Paper Shipping Name: Adhesive
Flash Point: 100??F (38??C).
NTP: No Dot Hazard Class: 3 Flammable Liquid
Under Explosion Limits: Not determined
IARC Monographs: No Identification Number: Not determined
Sensitivity to Static Discharge: Flammable
OSHA Regulated: No Volatile Organic Content: 250g/l
Lower Explosion Limits: Not determined
Irritant: Yes Label Requirements: California Proposition 65:
Extinguishing Media: Standard fire extin-
Sensitizer: Yes Warning! The state of California has determined
guisher, regular foam, and dry chemical dioxide.
that one or more substances in this product has
Foam and water fog is effective but may cause Mutagenic: No
caused cancer or reproductive disorders in
frothing. Do not use water. Petroleum-based Teratogenic: No laboratory animals.
compounds can float on water.
Special Fire Fighting Procedures: The use of
SECTION 7
self-contained breathing apparatus is recom- The information contained herein is based on
PRECAUTIONS FOR SAFE HANDLING
mended for firefighters. the best data available to us at the time of
AND USE publication and is believed to be correct.
Unusual Fire and Explosion Hazards: None
However, Sandell Mfg. Co. makes no warranty,
known Leak & Spill Procedures: Remove all sources
expressed or implied, regarding the accuracy of
of ignition. Use adequate ventilation to promote
Flammability: Flammable
this data or the results to be obtained from the
drying. Soak up liquid with absorbent material
Under What condition: Do not expose primer use thereof. Sandell Mfg. Co. assumes no
and remove in appropriate, closed containers.
to heat, flame, sparks or other sources of responsibility for damage or injury that may
Wash area with mild detergent and rinse
ignition. arise from the use of the material described
thoroughly with water.
herein.
Waste Disposal Method: Dispose in a
licensed waste disposal facility in accordance
with all applicable federal, state and local laws,
codes and regulations.


3-(isodecyloxy)propylammonium acetate