6189-41-9Relevant academic research and scientific papers
2,3-Butanediol dehydration catalyzed by silica-supported alkali phosphates
Kim, Wooyoung,Shin, Wookyun,Lee, Kyoung Jun,Cho, YongSeok,Kim, Hyung Soon,Filimonov, Igor N.
, p. 148 - 163 (2018/11/26)
Characterization of acid-base centers and catalytic dehydration of 2,3-butanediol (BDO) was performed over a wide range of silica-supported alkali phosphates (M_P/SiO2; M = Na, K, Cs; M:P = 0.5–3 mol:mol). Selectivity to 1,3-butadiene (BD) and 3-butene-2-ol (3B2OL) formed by elimination correlates with the densities of conjugated acid-base pairs and increases in the order Na ??M+ moieties. Isolated Br?nsted acid centers are probably silica grafted phosphoric acid molecules at low M/P and –PO(OH)2 end groups of oligophosphates at M/P > 1.5. Deactivation rate increases with the increase of M/P ratio in order Na K Cs. Deactivation patterns imply that sites responsible for elimination are active in dehydrative epoxidation. Dehydration of 3B2OL smoothly proceeds to BD, but the catalysts deactivate faster compared to BDO dehydration.
Oxidation of lower alkenes by Α-oxygen (FeIII–O??)Α on the FeZSM-5 surface: The epoxidation or the allylic oxidation?
Starokon, Eugeny V.,Malykhin, Sergei E.,Parfenov, Mikhail V.,Zhidomirov, Georgy M.,Kharitonov, Alexander S.
, p. 43 - 51 (2017/11/15)
Reactions of anion-radical α-oxygen (FeIII–O??)α with propylene and 1-butene on sodium-modified FeZSM-5 zeolites were studied in the temperature range from ?60 to 25 °C. Products were extracted from the zeolite surface and identified. It was found that main reaction pathway was the epoxides formation. Selectivity for epoxides at ?60 °C was 59–64%. Other products were formed as a result of secondary transformations of epoxides on the zeolite surface. According to IR spectroscopy, the oxidation of propylene over the entire temperature range and 1-butene at ?60 °C were not accompanied by the formation of (FeIII–OH)α groups, in distinction to methane oxidation. This testifies that hydrogen abstraction does not occur. In case of 1-butene reaction with α-oxygen at 25 °C, hydrogen abstraction occurred but was insignificant, ca 7%. According to DFT calculation ferraoxetane intermediate formation is preferable over hydrogen abstraction. Following decomposition of this intermediate leads to the propylene oxide (PO) formation. The results may be relevant to the low selectivity problem of the silver catalyst in propylene epoxidation and raise doubts about the presently accepted mechanism explaining an adverse effect of allylic hydrogen.
A method for preparing epoxy butane
-
Paragraph 0019; 0020, (2017/03/08)
The invention relates to a method for preparing epoxy butane, which comprises the following step: in an isopropyl benzene solution containing 25 wt% of cumene hydroperoxide solute, preparing epoxy butane from butylene oxide by using the cumene hydroperoxide solute as an oxidizer and a titanium-silicon molecular sieve with three-dimensional pore canal structure as a catalyst, wherein the fixed bed reaction conditions are as follows: the mole ratio of butylene to the cumene hydroperoxide solute is (5.0-12.0):1, the weight hourly space velocity of the cumene hydroperoxide is 1.0-5.0 h, the reaction pressure is 1.0-6.0 MPa, and the temperature is 60.0-120.0 DEG C. The catalyst is the titanium-silicon molecular sieve with three-dimensional pore canal structure; the molecular sieve has hysteresis loop on the low-temperature nitrogen adsorption and desorption isotherm; the average pore size is 2.0-8.0nm, and the specific area is 650.0-1100.0 m/g; and the catalyst has the advantages of favorable activity and high epoxy butane selectivity, and can be widely popularized and applied to industrial production of epoxy butane by butylene epoxidation.
A comprehensive test set of epoxidation rate constants for iron(IV)-oxo porphyrin cation radical complexes
Sainna, Mala A.,Kumar, Suresh,Kumar, Devesh,Fornarini, Simonetta,Crestoni, Maria Elisa,De Visser, Sam P.
, p. 1516 - 1529 (2015/03/04)
Cytochrome P450 enzymes are heme based monoxygenases that catalyse a range of oxygen atom transfer reactions with various substrates, including aliphatic and aromatic hydroxylation as well as epoxidation reactions. The active species is short-lived and difficult to trap and characterize experimentally, moreover, it reacts in a regioselective manner with substrates leading to aliphatic hydroxylation and epoxidation products, but the origin of this regioselectivity is poorly understood. We have synthesized a model complex and studied it with low-pressure Fourier transform-ion cyclotron resonance (FT-ICR) mass spectrometry (MS). A novel approach was devised using the reaction of [FeIII(TPFPP)]+ (TPFPP = meso-tetrakis(pentafluorophenyl)porphinato dianion) with iodosylbenzene as a terminal oxidant which leads to the production of ions corresponding to [FeIV(O)(TPFPP+a?￠)]+. This species was isolated in the gas-phase and studied in its reactivity with a variety of olefins. Product patterns and rate constants under Ideal Gas conditions were determined by FT-ICR MS. All substrates react with [FeIV(O)(TPFPP+a?￠)]+ by a more or less efficient oxygen atom transfer process. In addition, substrates with low ionization energies react by a charge-transfer channel, which enabled us to determine the electron affinity of [FeIV(O)(TPFPP+a?￠)]+ for the first time. Interestingly, no hydrogen atom abstraction pathways are observed for the reaction of [FeIV(O)(TPFPP+a?￠)]+ with prototypical olefins such as propene, cyclohexene and cyclohexadiene and also no kinetic isotope effect in the reaction rate is found, which suggests that the competition between epoxidation and hydroxylation - in the gas-phase - is in favour of substrate epoxidation. This notion further implies that P450 enzymes will need to adapt their substrate binding pocket, in order to enable favourable aliphatic hydroxylation over double bond epoxidation pathways. The MS studies yield a large test-set of experimental reaction rates of iron(iv)-oxo porphyrin cation radical complexes, so far unprecedented in the gas-phase, providing a benchmark for calibration studies using computational techniques. Preliminary computational results presented here confirm the observed trends excellently and rationalize the reactivities within the framework of thermochemical considerations and valence bond schemes.
Gas-phase dehydration of vicinal diols to epoxides: Dehydrative epoxidation over a Cs/SiO2 catalyst
Kim, Tae Yong,Baek, Jayeon,Song, Chyan Kyung,Yun, Yang Sik,Park, Dae Sung,Kim, Wooyoung,Han, Jeong Woo,Yi, Jongheop
, p. 85 - 99 (2015/09/28)
A novel type of dehydration reaction that produces epoxides from vicinal diols (dehydrative epoxidation) using a basic catalyst is reported. Epoxyethane, 1,2-epoxypropane, and 2,3-epoxybutane were produced from the dehydrative epoxidation of ethylene glycol, 1,2-propanediol, and 2,3-butanediol, respectively. Among a number of tested basic catalysts, the Cs/SiO2 catalyst showed outstanding performance for the dehydrative epoxidation of 2,3-butanediol and is considered to be the most promising catalyst for this type of reaction. In order to identify the superiority of the Cs/SiO2 catalyst and a mechanism of the reaction, structure-activity relationships were studied along with density functional theory (DFT) calculations. The following features are found to be responsible for the excellent activity of the Cs/SiO2 catalyst: i) strong basic sites formed by Cs+, ii) low penetration of Cs+ into SiO2 which permits basic sites to be accessible to the reactant, iii) stable basic sites due to the strong interactions between Cs+ and SiO2 surface, and iv) mildly acidic surface of SiO2 which is advantageous for the elimination to H2O. In addition, the dehydrative epoxidation involves an inversion of chirality (e.g. meso-2,3-butanediol (R,S) to trans-2,3-epoxybutane (R,R or S,S)), which is in agreement with DFT results that the reaction follows a stereospecific SN2-like mechanism.
Catalytic epoxidation of olefins in the presence of a vanadyl porphyrin complex
Miralamov,Mamedov
, p. 25 - 27 (2007/10/03)
It was found that vanadyl porphyrin complexes synthesized from petroleum metal porphyrin concentrates stimulated epoxidation during the olefin oxygenation process. The yields of obtained oxiranes turned out to be 38-75%, depending on the olefin structure. An epoxidation mechanism that suggests the formation of a protonated dioxygen adduct as an intermediate during oxygenation of olefins in the presence of vanadyl porphyrin complexes was proposed. An analogy is drawn between the epoxide formation reaction upon the catalytic oxygenation of olefins and the Prilezhaev reaction. MAIK "Nauka/Interperiodica".
Surface-modified mixed oxides containing noble metal and titanium for the selective oxidation of hydrocarbons
-
Page 10, (2008/06/13)
This invention relates to a process for the production of a composition containing gold and/or silver particles, mixed oxides containing titanium and silicon which have been surface-modified, to the compositions producible in this process and to the use thereof in processes for the selective oxidation of hydrocarbons in the presence of oxygen and a reducing agent. The catalytically active compositions exhibit constantly high selectivities and productivities.
Sol-gel hybrid materials containing precious metals as catalysts for partial oxidation of hydrocarbons
-
Page 17, (2010/02/07)
The present invention relates to a process for preparing a composition containing gold and/or silver particles and an amorphous, organic/inorganic titanium/silicon mixed oxide, the compositions which can be prepared by this process and their use as catalysts for the selective oxidation of hydrocarbons.
Catalyst for use in production of epoxide, method for producing the catalyst, and method for producing epoxide
-
, (2008/06/13)
To provide an epoxide-production-use catalyst that is suitably used for producing an epoxide by partial oxidation of an unsaturated hydrocarbon, a catalyst in accordance with the present invention is obtained by fixing gold fine particles to a carrier containing an oxide containing at least one of titanium and zirconium, and has an acid quantity of not more than 0.1 mmol/g determined by the NH3-TPD method. Such a catalyst for epoxide producing use can be produced by, for instance, fixing gold fine particles to a carrier having an acid quantity of not more than 0.15 mmol/g. The catalyst for epoxide producing use arranged as above is preferably used as a catalyst in partial oxidation of an unsaturated hydrocarbon to produce a corresponding epoxide.
8-HYDROXY-SUBSTITUTED ISOCOUMARINS BY LITHIATION OF BENZENE DERIVATIVES PROMOTED BY β-FUNCTIONALISED ALKYL GROUPS. A REGIOSELECTIVE AND SIMPLE SYNTHESIS OF OOSPOLACTONE
Ramacciotti, Alessio,Fiaschi, Rita,Napolitano, Elio
, p. 111 - 114 (2007/10/02)
3-(3-hydroxyphenyl)-2-butanone (obtained in 3 steps from 3-bromophenol and 3-chloro-2-butanone) was ketalised with ethylene glycol and protected at the phenolic OH as the methoxymethyl ether.The intermediate diacetal thus obtained underwent hydrogen-metal exchange with n-butyllithium; the metallated intermediate, after carbonation, methanolysis of acetal groups and elimination of methanol, regioselectively afforded the title compound (8-hydroxy-3,4-dimethylisocoumarin).
