1702
D. J. Segobia et al. / Chinese Journal of Catalysis 40 (2019) 1693–1703
References
Confined Ni0
particles
Reducible Ni
Phyllosilicate 1:1
Non-reducible Ni
Phyllosilicate 2:1
[1] S. T. McMillan, P. K. Agrawal, Ind. Eng. Chem. Res., 1988, 27,
243–248.
[2] C. De Bellefon, P. Fouilloux, Catal. Rev. Sci. Eng., 1994, 36, 4,
59–506.
H2
850 K
[3] P. Sabatier, J. B. Senderens, Compt. Rend. Acad. Sci., 1905, 140,
482–483.
[4] J. Von Braun, G. Blessing, F. Zobel, Ber. Dtsch. Chem. Ges., 1923, 36,
1988–2001.
[5] R. E. Juday, H. Adkins, J. Am. Chem. Soc., 1955, 77, 4559–4564.
[6] H. Greenfield, Ind. Eng. Chem. Prod. Res. Dev., 1967, 6, 142–144.
[7] P. Schärringer, T. E. Müller, J. A. Lercher, J. Catal., 2008, 253,
167–179.
SiO2
SiO2
O, OH, or vacancy
Ni
Intimate contact
=
=
between Lewis acid
Si
sites and Ni0 particles
Fig. 11. Generation of dual Lewis acid-Ni0 sites on Ni/SiO2-A.
[8] J. Krupka, J. Pasek, Curr. Org. Chem., 2012, 16, 988–1004.
[9] Y. Huang, W. M. H. Sachtler, Appl. Catal. A, 1999, 182, 365–378.
[10] D. J. Segobia, A. F. Trasarti, C. R. Apesteguia, Appl. Catal. A, 2012,
445, 69–78.
[11] J. Volf, J. Pasek, Stud. Surf. Sci. Catal., 1986, 27, 105–144.
[12] D. J. Segobia, A. F. Trasarti, C. R. Apesteguía, Catal. Sci. Technol.,
2014, 4, 4075–4083.
[13] D. J. Segobia, A. F. Trasarti, C. R. Apesteguía, Catal. Commu., 2015,
62, 62–66.
[14] D. J. Segobia, A. F. Trasarti, C. R. Apesteguía, J. Braz. Chem. Soc.,
2014, 25, 2272–2279.
Like Ni/SiO2-A, Ni/SiO2-Al2O3-I contains Ni0 and Lewis acid
sites and produces mainly DBA and TBA with only minor
amounts of BA. Nevertheless, the DBA/TBA ratio was lower on
Ni/SiO2-A (1.1) than on Ni/SiO2-Al2O3-I (2.5). This is because
Ni/SiO2-A contains more and stronger acid sites than
Ni/SiO2-Al2O3-I and would promote better the surface reactions
leading to TBA which involve the strong adsorption of BA and
DBA intermediates.
[15] M. J. F. M. Verhaak, A. J. van Dillen, J. W. Geus, Catal. Lett., 1994, 26,
37–53.
5. Conclusions
[16] Y. Hao, X. Wang, N. Perret, F. Cardenas-Lizana, M. A. Keane, Catal.
Struct. React., 2015, 1, 4–10
[17] Y. Huang, V. Adeeva, W. M. H. Sachtler, Appl. Catal. A, 2000, 196,
73–85.
[18] J. T. Richardson, R. J. Dubus, J. Catal., 1978, 54, 207–218.
[19] O. Clause, M. Kermarec, L. Bonneviot, F. Villain, M. Che, J. Am. Chem.
Soc. 1992, 114, 4709–4717.
[20] M. Houalla, F. Delannay, I. Matsuura, B. Delmon, J. Chem. Soc., Far-
aday Trans 1, 1980, 76, 2128–2141.
[21] A. Barbier, A. Hanif, J. A. Dalmon, G. A. Martin, Appl. Catal. A, 1998,
168, 333–343.
[22] F. Le Normand, A. Borgna, T. F. Garetto, C. R. Apesteguia, B.
Moraweck, J. Phys. Chem., 1996, 100, 9068–9076.
[23] J. S. Smith, P. A. Thrower, M. A. Vannice, J. Catal. 1981, 68,
270–285.
[24] P. Burattin, M. Che, C. Louis, J. Phys. Chem. B, 1997, 101,
7060–7074.
[25] M. V. Sivaiaha, S. Petit, J. Barrault, C. Batiot–Dupeyrat, S. Valange,
Catal. Today, 2010, 157, 397–403.
[26] M. Che, Z. X. Cheng, C. J. Louis, Am. Chem. Soc., 1995, 117,
2008–2018
[27] M. G. da Fonseca, C. R. Silva, J. S. Barone, C. Airoldi, J. Mater. Chem.,
2000, 10, 789–795.
[28] G. W. Brindley, D. L. Bish, H. M. Wan, Am. Mineral., 1979, 64,
615–625.
[29] C. Zhang, H. Yue, Z. Huang, S. Li, G. Wu, X. Ma, J. Gong, ACS Sustain-
able Chem. Eng., 2013, 1, 161–173
The activity and selectivity of Ni/SiO2 catalysts for the liq-
uid-phase hydrogenation of butyronitrile to butylamine, dibu-
tylamine and tributylamine depend significantly on the catalyst
preparation method. Ni/SiO2 catalysts obtained by incipi-
ent-wetness impregnation (Ni/SiO2-I) do not contain acid sites
and the active sites are metallic Ni atoms located at the surface
of large Ni particles of low interaction with the support.
Ni/SiO2-I promotes the formation of butylamine, the primary
amine; here, the butylamine selectivity on Ni/SiO2-I was 80% at
complete conversion of butyronitrile at 373 K and 13 bar.
Ni/SiO2 catalysts prepared by the ammonia method
(Ni/SiO2-A) present highly dispersed Ni0 nanoparticles in close
contact with Ni phyllosilicates containing a high density of
Lewis acid sites. Ni/SiO2-A forms essentially similar amounts of
dibutylamine and tributylamine, and only negligible amounts of
butylamine. This is because butylamine is strongly adsorbed on
phyllosilicate acid sites and reacts on the catalyst surface with
adsorbed imine intermediates to form secondary and tertiary
amines, probably on the interphase of surface acid sites-Ni0
nanoparticles. The results presented in this work show that
selective formation of primary, secondary or tertiary amines
from nitrile hydrogenation on Ni/SiO2 may be tuned by select-
ing the proper catalyst preparation method.
Acknowledgments
[30] B. Mile, D. Stirling, M. A. Zammitt, A. Lovell, M. Webb, J. Catal.,
1998, 114, 217–229.
Authors thank the Universidad Nacional del Litoral (UNL),
Consejo Nacional de Investigaciones Científicas y Técnicas
(CONICET), and Agencia Nacional de Promoción Científica y
Tecnológica (ANPCyT), Argentina, for the financial support of
this work.
[31] K. Hadjiivanov, M. Mihaylov, D. Klissurski, P. Stefanov, N. Ab-
adjieva, E. Vassileva, L. Mintchev, J. Catal., 1999, 185, 314–323.
[32] A. Lewandowska, S. Monteverdi, M. Bettahar, M. Ziolek, J. Mol.
Catal. A, 2002, 188, 85–95.
[33] P. Castaño, B. Pawelec, J. L. G. Fierro, J. M. Arandes, J. Bilbao, Fuel,
2007, 86, 2262–2274.