280
L. Vanoye et al. / Applied Catalysis A: General 394 (2011) 276–280
greatly depends on bulk solvent properties. This study suggests
that solvent effect should be take into account in the modelling of
etherification and could explain the discrepancy observed between
models and experimental data obtained during liquid-phase forma-
tion of ethers.
References
[1] T.A. Semelsberger, R.L. Borup, H.L. Greene, J. Power Sources 156 (2006)
497–511.
[2] J. Bandiera, C. Naccache, Appl. Catal. 69 (1991) 139–148.
[3] G. Bercic, J. Levec, Ind. Eng. Chem. Res. 32 (1993) 2478–2484.
[4] W.Z. Lu, L.H. Teng, W.D. Xiao, Chem. Eng. Sci. 59 (2004) 5455–5464.
[5] M.P. Atkins, M.J. Earle, K.R. Seddon, M. Swadzba-Kwasny, L. Vanoye, Chem.
Commun. 46 (2010) 1745–1747.
Fig. 7. Influence of solvent properties on kinetic model (Eley–Rideal).
[6] S. Pariente, N. Tanchoux, F. Fajula, Green Chem. 11 (2009) 1256–1261.
[7] G.A. Olah, T. Shamma, G.K.S. Prakash, Catal. Lett. 46 (1997) 1–4.
[8] J. Tejero, F. Cunill, M. Iborra, J.F. Izquierdo, C. Fité, J. Mol. Catal. A. Chem. 182–183
(2002) 541–554.
[9] I. Hoek, T.A. Nijhuis, A.I. Stankiewicz, J.A. Moulijn, Appl. Catal. A 266 (2004)
109–116.
stitution (SN2). Thus, a decrease of reaction rate (Fig. 6) is observed
when the  parameter increases, a high  value involving a better
lyst can be increased by interaction with solvent capable of forming
strong hydrogen bonds with the anion of the catalytic site [33]. Such
properties can be evaluated using an ␣ scale of solvent hydrogen-
bond donor (HBD) [31,32]. In our case, among the solvents used
only ethanol has an ␣ parameter different than 0 (˛ = 0.83). In our
experiments, the amount of ethanol adsorb on the resin is believed
to decrease from alcanes to DMSO. A decrease of the local concen-
tration of ethanol and should decrease the strength of the catalyst.
Thus, ethanol concentration has a very complex effect on the reac-
tion rate: it increase the reaction rate by an increase of reactant
lyst (HBD parameter) but in the same time it slow down the reaction
rate as oxonium ion stabiliser (HBA parameter). The function, which
results of these antagonist parameters, is reported indirectly in
Figs. 2–4.
[10] F. Cunill, J. Tejero, C. Fite, M. Iborra, J.F. Izquierdo, Ind. Eng. Chem. Res. 44 (2005)
318–324.
[11] R. Bringué, M. Iborra, J. Tejero, J.F. Izquierdo, F. Cunill, C. Fité, V.J. Cruz, J. Catal.
244 (2006) 33–42.
[12] R. Bringué, J. Tejero, M. Iborra, C. Fite, J.F. Izquierdo, F. Cunill, J. Chem. Eng. Data
53 (2008) 2854–2860.
[13] J. Tejero, C. Fite, M. Iborra, J.F. Izquierdo, F. Cunill, R. Bringue, Micropor. Mesopor.
Mater. 117 (2009) 650–660.
[14] R. Bringué, J. Tejero, M. Iborra, J.F. Izquierdo, C. Fite, F. Cunill, Ind. Eng. Chem.
Res. 46 (2007) 6865–6872.
[15] J. Tejero, C. Fite, M. Iborra, J.F. Izquierdo, R. Bringue, F. Cunill, Appl. Catal. A 308
(2006) 223–230.
[16] R. Bringué, J. Tejero, M. Iborra, J.F. Izquierdo, C. Fite, F. Cunill, Top. Catal. 45
(2007) 181–186.
[17] E. Medina, R. Bringue, J. Tejero, M. Iborra, C. Fite, Appl. Catal. A 374 (2010) 41–47.
[18] S.-K. Ihm, J.-H. Ahn, Y.-D. Jo, Ind. Eng. Chem. Res. 35 (1996) 2946–2954.
[19] S. Koujout, D.R. Brown, Catal. Lett. 98 (2004) 195–202.
[20] J.M. Prausnitz, R.N. Lichtenthaler, E.G. Azevedo, Molecular Thermodynamics
of Fluid-Phase Equilibria, third ed., Prentice Hall PTR, Upper Saddle River, NJ,
U.S.A., 1999.
[21] ProSimPlus®: Steady-state simulation and optimization of processes, 2008.
[22] L. Degirmenci, N. Oktar, G. Dogu, Ind. Eng. Chem. Res. 48 (2009) 2566–2576.
[23] B.C. Gates, L.N. Johanson, J. Catal. 14 (1969) 69–76.
[24] T. Dogu, N. Boz, E. Aydin, N. Oktar, K. Murtezaoglu, G. Dogu, Ind. Eng. Chem.
Res. 40 (2001) 5044–5051.
4. Conclusion
The influence of the liquid phase composition on the initial
reaction rate of ethanol etherification has been investigated using
different sulfonic acid catalyst. For both heterogeneous and homo-
geneous sulfonic-acid catalysts it was observed that the initial
ethanol concentration has a complex effect on initial reaction rates.
Initial reaction rates depend on ethanol concentration but also on
bulk solvent properties.
From the data, we could conclude that the observed inflexion of
the initial reaction rate of the liquid phase dehydratation of ethanol
to diethylether in non polar solvents as the function of ethanol
concentration could be explain by the formation of a new liquid
phase around the acid site. The composition of this liquid phase
[25] R.G. Herman, F.H. Khouri, K. Klier, J.B. Higgins, M.R. Galler, C.R. Terenna, J. Catal.
228 (2004) 347–361.
[26] J.G. Nunan, K. Klier, R.G. Herman, J. Catal. 139 (1993) 406–420.
[27] J.G. Nunan, K. Klier, R.G. Herman, J. Catal. 141 (1993) 741.
[28] K. Klier, Q. Sun, O.C. Feeley, M. Johansson, R.G. Herman, 11th International
Congress on Catalysis – 40th Anniversary, Elsevier Science, 1996 (pp. 601–610).
[29] A.J. Parker, Chem. Rev. 69 (1969) 1–32.
[30] S.S. Shaik, J. Am. Chem. Soc. 106 (1984) 1227–1232.
[31] C. Reichardt, Solvents and Solvent Effects in Organic Chemistry, 3rd ed., Wiley-
VCH, New York, 2003.
[32] M.J. Kamlet, J.L.M. Abboud, M.H. Abraham, R.W. Taft, J. Org. Chem. 48 (1983)
2877–2887.
[33] D. Farcasiu, A. Ghenciu, G. Marino, K.D. Rose, J. Am. Chem. Soc. 119 (1997)
11826–11831.